Скачать книгу - Suzuki outboard motor DF40 / DF50, service e-manual (in Russian)

Content General information Warnings / precautions / notes General precautions Identification number location Fuel and oil Recommendations for the use of gasoline Engine oil Engine break-in Screws Specifications Maintenance data Torque Special tools Required materials Scheduled maintenance Planned maintenance schedule Planned maintenance scheme Maintenance and adjustment procedures Engine oil / engine oil filter Gear oil Grease Spark plug Spacer gap Idling Ignition timing Crankcase breather and fuel lines Low pressure fuel filter High pressure fuel filter Water pump / water pump impeller Anodes and connecting wires Battery Bolts and nuts Checking the fuel mixture (oxygen content) Oil pressure Cylinder compression Motor control systems ECM connector / terminal location Electronic control unit (ECM) Motor control wiring diagram Composition of the engine management system The internal structure of the ECM Sensors Ignition system Ignition control system Electronic fuel injection Fuel injector control system Fuel system components Fuel pump control system Air intake components Idle air control systems Warning system Over-rev alert system Low oil pressure warning system Overheat warning system Low battery alert Self-diagnosis system Priority / code / pattern for self-diagnosis system operation, system operation Operating conditions of the self-diagnosis system Self-preservation system Pre-programmed data for self-preservation system Systems for displaying the number of hours worked Gear start protection system Exhaust oxygen control system Checks and precautions for checks ECM voltage tests Resistance tests Other checks Troubleshooting Dismantling / installation Flywheel / TFR sensor / CMR sensor Oil pressure sensor Electrical Battery charging system Engine start system Starter motor Display - tachometer Engine Intake manifold Engine Oil pump / housing Measurement of pump components Timing chain / tensioner Cylinder head Cylinder / crankshaft / piston Thermostat Water cooling system Engine lubrication system Fuel system Precaution on fuel system service Fuel line Carburetors Fuel pump Fuel tank and fuel cock Middle part Side engine cover Driveshaft housing and oil pan Swivel bracket, steering column bracket and clamp bracket Trim and recline system System wiring diagram maintenance Oil level Air vent PTT block PTT engine PTT motor relay PTT switch Gear unit Drive gear bearing Propeller Reducer Gears Propeller shaft elements Propeller shaft bearing support Shift rod and rods Water pump and component parts Bearing housing for input shaft seals Drive shaft Propeller shaft elements Propeller shaft bearing support Shift rod and rods Water pump and component parts Bearing housing for input shaft seals Drive Shaft Transom board Adjustment and adjustment of gears gearbox Electrical wiring / hose connection Wiring diagram Wiring Laying fuel and water hoses DF40QH / 50QH Specifications Service data Torque Wiring diagram Engine control system Middle section Auxiliary leg lift system Model DF40/50 “Y” (’00) Service information Engine control system Electrical Engine Reducer Wiring / hoses Model DF40/50(W) “K1” (’01) General information Specifications Service data tightening torque Special tools Required materials Periodic maintenance maintenance and adjustment procedures motor control system Motor control device Ignition system Electronic fuel injection Self-diagnosis system Health saving system Hours indication system Oil change reminder system Inspection and troubleshooting Electrical Starter electrical system Middle section Assisted tilt system Hydro tipping system Hydraulic tipping unit Laying wires / hoses Wiring diagram Model DF40/50 “KZ” (’03) Specifications Maintenance data ECM main relay Exhaust manifold temperature sensor and cylinder temperature sensor Cylinder block Buzzer Neutral sensor bracket Lower part of oil seal housing Front gear thrust washer Exhaust camshaft Wiring diagrams Hoses Получить ссылку