Скачать книгу - Toyota Celica since 1988, service e-manual

Content Introduction How to use this manual Identification information General repair instructions Precautions for vehicles equipped with a catalytic converter Precautions when servicing full-time 4WD vehicles Precautions when towing full-time 4WD vehicles Vehicle lift and support locations Abbreviations used in this manual Maintenance Maintenance schedule Maintenance operations General maintenance Engine mechanical Description Troubleshooting Engine tune-up Compression check Timing belt Cylinder head Cylinder block Turbocharger system Description Precautions Troubleshooting Check and replacement of intercooler coolant Turbocharger Intercooler Emission control systems System purpose Component layout and schematic drawing Positive crankcase ventilation (PCV) system Fuel evaporative emission control (EVAP) system Exhaust gas recirculation (EGR) system Three-way catalyst (TWC) system EFI system System description Troubleshooting Diagnosis system Troubleshooting with volt / ohmmeter Fuel system Fuel pump Cold start injector Fuel pressure regulator Injectors Fuel tank and lines Air induction system Throttle body Idle speed control (ISC) valve Electronic control system Location of electronic control parts Circuit opening relay Fuel pump relay and resistor Solenoid resistor Cold start injector time switch T-VIS VSV EGR control VSV Turbocharging pressure sensor Turbocharging pressure VSV Electronic controlled unit (ECU) Fuel cut RPM High-temperature line pressure up system Cooling system Description Check and replacement of engine coolant Electric cooling fan Lubrication system Description Oil pressure check Replacement of engine oil and oil filter Oil cooler and relief valve Oil nozzles and check valves Ignition system Precautions Troubleshooting Ignition system circuit On-vehicle inspection Distributor Starting system Starter Clutch Clutch unit Manual transaxle Description Precautions Troubleshooting Removal and installation of transaxle Removal of component parts Component parts Input shaft assembly Output shaft assembly Oil pump Shift and select lever shaft Differential case Transfer Installation of component parts Shift lever and control cable Propeller shaft Precaution Troubleshooting Propeller shaft Front axle and suspension Troubleshooting Front wheel alignment Front drive shaft Front suspension Stabilizer bar Rear axle and suspension Troubleshooting Rear wheel alignment Rear axle hub and carrier Rear drive shaft Differential Rear suspension Suspension arm Brake system Front brake Rear brake Anti-lock brake system (A.B.S.) Description Diagnosis system Troubleshooting Speed sensor diagnosis system Deceleration sensor operation diagnosis system Brake actuator Control relays Front speed sensor Rear speed sensor Anti-lock brake system circuit Steering Power steering Power steering pump Gear housing Body electrical system Location of switches and relays Lighting Instruments, gauges and warning lights Audio system Body Moulding Seat belt Body dimensions Air conditioning system Air conditioning system circuit Condenser fan motor Condenser fan control amplifier Sensor Service specifications Maintenance Engine mechanical Turbocharger system EFI system Cooling system Lubrication system Ignition system Starting system Charging system Clutch Manual transaxle Propeller shaft Front axle and suspension Rear axle and suspension Brake system Steering Lubricant Standard bolt torque specifications SST AND SSM SST (special service tools) SSM (special service Electrical wiring diagrams Получить ссылку