Скачать книгу - Jeep Compass since 2011 (+ update 2013), wiring diagrams (in Russian)

Содержание

Введение

Действия в чрезвычайных ситуациях

• Аварийная световая сигнализация
• Перегрев двигателя
• Перегрев автоматической коробки передач
• Замена поврежденного колеса
• Запуск двигателя от внешнего источника электроэнергии
• Движение на скользких дорогах
• Выезд методом раскачивания
• Электрические плавкие предохранители (коммутационный блок — IPM)
• Буксировка автомобиля

Поездка на СТО

Инструкция по эксплуатации и обслуживанию автомобиля

• Эксплуатация автомобиля
• Обслуживание автомобиля
• Технические данные

• Базовый комплект необходимых инструментов
• Методы работы с измерительными приборами

• Технические данные
• Обслуживание
• Привод газораспределительного механизма
• Головка блока цилиндров и газораспределительный механизм
• Кривошипно-шатунный механизм
• Приложение к главе

• Ремень привода навесного оборудования
• Зубчатый ремень привода ГРМ
• Головка блока цилиндров

• Технические данные
• Система питания бензиновых двигателей
• Система питания дизельных двигателей
• Приложение к главе

• Диагностика системы
• Замена моторного масла
• Масляный фильтр
• Масляный поддон
• Датчик температуры моторного масла
• Охладитель моторного масла
• Масляный насос
• Приложение к главе

• Обслуживание
• Расширительный бачок
• Нагреватель блока цилиндров
• Датчик температуры охлаждающей жидкости
• Термостат
• Радиатор
• Вентилятор охлаждения радиатора
• Водяной насос
• Охладитель EGR (система рециркуляции отработанных газов)
• Приложение к главе

• Система впуска
• Система выпуска
• Приложение к главе

• Коробка передач в сборе
• Дифференциал
• Раздаточная коробка
• Приложение к главе

• Обслуживание
• Элементы сцепления
• Гидропривод выключения сцепления
• Приложение к главе

• Вариатор в сборе
• Механизм переключения
• Главная передача

• Передние приводные валы
• Задние приводные валы
• Карданный вал
• Приложение к главе

• Технические данные
• Передняя подвеска
• Задняя подвеска
• Колеса и шины
• Приложение к главе

• Технические данные
• Обслуживание тормозной системы
• Тормозные механизмы
• Гидропривод тормозной системы
• Стояночный тормоз
• Антиблокировочная система тормозов
• Приложение к главе

• Обслуживание рулевого управления
• Рулевая колонка
• Рулевой механизм
• Насос гидравлического усилителя рулевого управления
• Приложение к главе

• Экстерьер
• Интерьер
• Остекление
• Двери
• Сиденья
• Кузовные размеры
• Приложение к главе

• Общие сведения и меры предосторожности
• Подушки безопасности
• Ремни безопасности
• Приложение к главе

• Технические характеристики
• Система кондиционирования и вентиляции
• Система отопления
• Приложение к главе

• Система подзарядки
• Система пуска
• Система зажигания
• Приложение к главе

• Аудиосистема
• Навигационная система
• Подогрев сидений
• Звуковой сигнал
• Система обмена сообщениями
• Очистители и омыватели стекол
• Система внешнего освещения
• Подогрев заднего стекла

Content

Actions in emergency situations

• First aid kit and emergency sign
• Starting the engine from an external power source
• Fuse replacement
• Towing a car

• General information
• Controls, dashboard, interior equipment
• Caring for the body and the car
• Car maintenance

• Basic set of necessary tools
• Methods of working with measuring devices

• Car service
• Removing and installing engine
• Multi-function bracket
• V-belt drive for auxiliary equipment
• Seals and O-rings
• Crankshaft pulley
• Gear timing belt (timing chain)
• Cylinder head
• Cylinder block
• Engine mount
• Service data and specification

• General information
• Car service
• Radiator cooling system
• Coolant pump
• Thermostat
• Engine cooling fan
• Block of immersion heaters (heaters)
• Expansion tank
• Coolant pump feed pipe
• Service data and specification

• Car service
• Oil filter
• Oil filter housing
• Water-cooled cooler
• Oil pressure switch
• The gauge of level of oil
• Oil pump
• Nozzles for spraying oil
• Service data and specification

• Precautions for repair
• Fuel filter
• High-pressure fuel pump (fuel pump)
• Nozzle
• Fuel pressure regulator
• Fuel distribution ramp
• Fuel tank
• Service data and specification

• Injection computer
• Various sensors
• Air intake flaps
• Accelerator pedal
• Service data and specification

• Intake manifold
• Exhaust manifold
• Exhaust pipelines and mufflers
• Turbocharging
• Exhaust gas recirculation system
• Service data and specification

• Charge system
• Starting system
• Prepostheating system
• Service data and specification

• General information
• Precautions for repair
• Car service
• Disassembly and assembly operations
• Master cylinder
• Clutch slave cylinder
• Hydraulic clutch drive
• Clutch pedal and clutch pedal switch
• Service data and specification

• Manual transmission
• Robotic manual transmission
• Service data and specification

• Precautions for repair
• Drive shafts
• Differential
• Service data and specification

• General information
• Front suspension
• Rear suspension
• Pneumatic suspension
• Wheels and tires
• Service data and specification

• General information
• Car service
• Components of the braking system
• Front brakes
• Rear brakes
• Parking brake system
• Anti-lock braking system (ABS)
• Service data and specification

• Steering complete
• Power steering system
• Service data and specification

• General information
• Interior
• Exterior
• Sunroof in the ceiling
• Body dimensions
• Service data and specification

• General information
• Airbag computer
• Airbag modules
• Seat belt pretensioners and seat belts
• Detoxication of airbag and pretensioners modules
• Service data and specification

• Heating system
• Stand-alone (additional) heater
• Air conditioning system
• Service data and specification

• Description of electrical circuits
• Ground connection points
• Electroschemes

• Abbreviations

Content

Actions in emergency situations

• Sign of emergency stop
• First aid kit
• Fire extinguisher
• Toolbox
• Wheel replacement
• Tire repair
• Starting the engine
• Electrical fuses and incandescent lamps
• Towing a car

• Technical information of the car
• Controls, dashboard, interior equipment
• Caring for the body and the car
• Car maintenance

• Basic set of necessary tools
• Methods of working with measuring devices

• Engine specifications
• Gasoline engine with direct injection of 3.6 liters (FSI)
• Gasoline engine with direct injection 4.2 liters (FSI)
• Diesel engine 3.0 l (TDI)
• Diesel engine 4.2 liters (TDI)
• Diesel engine 6.0 liters (TDI)
• Gasoline engine 3.0 liters (TFSI)
• Annex to chapter

• Gasoline engines
• Diesel engines
• Annex to chapter

• Ignition system
• Charge system
• Launch system
• Annex to chapter

• Cooling system (3.6FSI engine)
• Cooling system (4.2FSI engine)
• Cooling system (3.0TDI engine)
• Cooling system (engine 4,2TDI)
• Cooling system (engine 6,0TDI)
• Annex to chapter

• Lubrication system (engine 3,6FSI)
• Lubrication system (4.2FSI engine)
• Lubrication system (3.0TDI engine)
• Lubrication system (engine 4,2TDI)
• Lubrication system (engine 6,0TDI)
• Annex to chapter

• Release system (3.6FSI engine)
• Release system (4.2FSI engine)
• Release system (3.0TDI engine)
• Release system (engine 4,2TDI)
• Release system (engine 6,0TDI)
• Annex to chapter

• Dashboard
• Windshield wipers and washers
• Lighting devices
• Lights and lights
• Other equipment
• Annex to chapter

• Mechanical 6-speed gearbox 08D
• Automatic transmission 0ATA
• Automatic transmission 0BQ
• Automatic transmission 09D
• Eight-speed automatic transmission 0C8
• Annex to chapter

• Transfer case
• Annex to chapter

• Suspension of the front wheels
• Annex to chapter

• Suspension of rear wheels
• Annex to chapter

• Steering
• Annex to chapter

• Mechanics of the braking system
• Hydraulics of brake system
• Annex to chapter

• External bodywork
• Interior layout
• Annex to chapter

• Passive safety system
• Airbags
• Annex to chapter

• Autonomous / additional heater
• Air conditioning
• Annex to chapter

Content

Your BMW 3 series car

• Introduction
• Safety first!
• Troubleshooting an emergency
• Starting the engine from an additional power source
• Wheel replacement
• Towing
• Leak detection
• Weekly checks
• Checks under the hood of the car
• Engine oil level
• Coolant level
• Level of a brake liquid and a working liquid of coupling
• Power steering fluid
• Electrical systems
• Tire condition and air pressure
• Battery
• Working fluids and lubricants

• Overview of the dashboard, warning lights and devices
• Controls
• Cruise control system
• Air conditioning system with manual control and automatic operation
• Storage bays and other interior components

• Introduction
• Regular maintenance
• TO-2
• Resetting maintenance interval (CBS) display mode
• Maintenance of front brakes
• Maintenance of rear brakes
• Car inspection
• Replacement of air filter
• Replacement of spark plugs
• Brake fluid replacement
• Checking and replacing the auxiliary drive belt
• Replacing the fuel filter
• Replacing coolant

• Introduction
• Regular maintenance
• TO-2
• Resetting maintenance interval (CBS) display mode
• Maintenance of front brakes
• Maintenance of rear brakes
• Car Inspection
• Replacement of the air filter (keys 2/5)
• Replacing the main fuel filter
• Replacing the particulate filter
• Brake fluid replacement
• Checking and replacing the auxiliary drive belt
• Changing the coolant

• General information
• Compression check - description and explanation
• Determination of the top dead center for the cylinder 1 piston
• Cylinder head cover - removal and installation
• Torsion damper / pulley and crankshaft pulley hub - removal and installation
• Chains of drive timing - removal, inspection and installation
• Asterisks and timing chain tensioner - removal and installation
• Phase Shifter - description and replacement of components
• Camshafts and pushers
• Cylinder head - removal and installation
• Crankcase - removal and installation
• Front frame reinforcement - removal and installation
• Front subframe - lowering, removal and installation
• Balancing shafts - general information
• Oil pump - removal, inspection and installation
• Oil seals - replacement
• Handwheel / drive clutch plate - Removing and installing
• Centering Crankshaft Bearing - Replacement
• Engine / gearbox mountings - check and replace
• Engine oil level and pressure sensors

• General information
• Compression check - description and explanation
• Determination of the top dead center for the cylinder 1 piston
• Cylinder head cover - removal and installation
• Torsional vibration damper - removal and installation
• Chain of drive timing - removal, inspection and installation
• Components of the valve timing system (Vanos) - removal, inspection and installation
• Camshafts and pushers
• Components of the Valvetronic system - removal and installation
• Cylinder head - removal and installation
• Crankcase - removal and installation
• Oil pump - removal, inspection and installation
• Oil seals - replacement
• Handwheel / drive clutch plate - removing and installing
• Engine / gearbox mountings - flywheel guide bearing - check, remove and install
• Engine oil level and pressure sensors

• General information
• Compression check - description and explanation
• Engine assembly / valve timing - general information and usage
• Cylinder head cover - removal and installation
• Crankshaft pulley / torsional vibration damper - Removing and installing
• Camshafts, rocker arms and hydraulic lifters - removal, inspection and installation
• Cylinder head - removal and installation
• Crankcase - removal and installation
• Oil pump - removal, inspection and installation
• Balancing shaft assembly - removal and installation
• Oil cooler - removal and installation
• Crankshaft oil seals - replacement
• Handwheel / drive clutch plate - Removing and installing
• Engine supports - checking and replacing
• Flywheel guide bearing - check, remove and install
• Chains for timing and cover - removal and installation
• Engine oil level and pressure sensors

• General information
• Compression check - description and explanation
• Engine assembly / valve timing - general information and usage
• Cylinder head cover - removal and installation
• Crankshaft pulley / torsional vibration damper - removing and installing
• Camshafts, rocker arms and hydraulic lifters - removal, inspection and installation
• Cylinder head - removal and installation
• Crankcase - removal and installation
• Oil pump / vacuum pump - removal, inspection and installation
• Balancer shaft assembly - general information
• Oil cooler - removal and installation
• Crankshaft oil seals - replacement
• Handwheel / drive clutch plate - Removing and installing
• Engine supports - checking and replacing
• Flywheel guide bearing - check, remove and install
• Chains of drive timing and cover - general information
• Engine oil level and pressure sensors

• General information
• Major engine repairs - general information
• Engine removal - methods and precautions
• Engine - removal and installation
• Engine overhauling - sequence of disassembly
• Cylinder head - disassembly
• Cylinder head and valves - cleaning and checking
• Cylinder head - assembly
• Piston / connecting rod assembly - removal
• Timing drive chain (diesel engines N47 and N57) - removal and installation
• Crankshaft removal
• Cylinder block / crankcase - cleaning and inspection
• Piston / connecting rod assembly - check
• Crankshaft check
• The crankshaft bearing and thrust bearing - check
• Overhauling - assembly sequence
• Piston rings - installation
• Crankshaft - installation
• Pistons / connecting rods in assembly - installation
• Engine - operation after major repairs

• General information and precautions
• Cooling hoses - detach and replace
• Radiator - removal, inspection and installation
• Thermostat - removal and installation
• Cooling fan and viscous coupling - removal and installation
• Electric cooling fan and casing - Removing and installing
• Electrical sensors for the cooling system - checking, removing and installing
• Water pump - removal and installation
• Heater and ventilation system - general information
• Components of the heater / ventilation system - removal and installation
• Air conditioning system - general information and precautions
• Components of the air conditioning system - removal and installation
• Heating element for auxiliary heater - removal and installation
• Shutters and servomotor for adjusting the intensity of the radiator airflow - removal and installation

• General information and precautions
• Air filter assembly - removing and installing
• Fuel tank - removal and installation
• Accelerator pedal - removal and installation
• Fuel injection system - general information
• Fuel injection system - pressure relief and refueling
• Fuel pump / fuel level sensors - Removing and installing
• Fuel injection system - check and adjustment
• Throttle body - removing and installing
• Components of the distributed fuel injection system - removal and installation
• Collectors - removal and installation

• Power and exhaust system - diesel engines General information and precautions
• Air filter assembly - removing and installing
• Fuel tank - removal and installation
• Accelerator pedal - removal and installation
• Fuel injection system - general information
• Fuel injection system - pressure relief and refueling
• Fuel pump / fuel level sensors and control unit - removal and installation
• Fuel injection system - check and adjustment
• High-pressure fuel pump (fuel pump) - Removing and installing
• Fuel injectors - removal and installation
• Components of the electronic engine management (EDC) - removal and installation
• Turbocharger - description and precautions
• Turbocharger - removal and installation
• Turbocharger - check and overhaul
• Intercooler - removing and installing
• Collectors - removal and installation
• Exhaust system - general information and replacement

• General Information
• Emission control systems (gasoline engines) - checking and replacing components
• Emission control systems (diesel engines) - checking and replacing components
• Catalytic converter - general information and precautions

• General information and precautions
• Detection of malfunctions in the electrical system - general information
• Battery - check and charge
• Storage battery - detachment, removal and installation
• Charge system - check
• Generator drive belt - removal, installation and tension
• Generator - removal and installation
• Generator - check and overhaul
• Startup system - check
• Starter - removal and installation
• Starter - check and overhaul
• Preheating system for diesel engines - description and verification
• Glow plugs - removal, inspection and installation
• Control unit / relay for pre- and post-heating systems - removal and installation

• General information and precautions
• Ignition system - check
• High-voltage ignition coils - removal and installation
• Detonation sensor - removal and installation

• General information
• Clutch assembly - removal, inspection and installation
• Clutch release bearing and lever - removal, inspection and installation
• The working cylinder - removal, check and installation
• Master cylinder - removal, inspection and installation
• Hydraulic clutch circuit - pumping
• Clutch pedal - removal and installation

• General information
• Checking the transmission oil level
• Replacing gearbox oil
• Components of the gearshift mechanism - removal and installation
• Oil seals - replacement
• Switch for reversing lights - check, remove and install
• Manual gearbox - Removing and installing
• Major overhaul of a manual transmission - general information

• General information
• Selector lever - removal and installation
• Cable of the selector lever - removal, installation and adjustment
• Oil seals - replacement
• Automatic gearbox - removal and installation
• Overhaul of an automatic transmission - general information
• Electronic components / sensors - removal and installation
• Checking the automatic transmission fluid level
• Automatic transmission replacement

• General information
• The main gear assembly is removal and installation
• Seals of the final drive assembly - replacement
• Drive shafts - removal and installation
• Anthers of drive shafts - replacement
• Drive shaft - removal and installation
• Rubber coupling propshaft - check and replace
• PTO shaft bearing - checking and replacing
• Universal joints of the propshaft - check and replace
• Checking the final drive oil level

• General information
• Hydraulic system - air removal
• Hydraulic connections and hoses - replacement
• Front brake pads are replacement
• Rear brake pads - replacement
• Front brake disc - check, remove and install
• Rear brake disc - check, remove and install
• Front brake caliper - removal, overhaul and installation
• Rear brake caliper - removal, overhaul and installation
• Master brake cylinder - removal, overhaul and installation
• Brake pedal - removal and installation
• Vacuum brake booster - checking
• The check valve of the vacuum amplifier of brakes - removal, check and installation
• Parking brake - adjustment
• Parking brake lever - removal and installation
• Parking brake cables - removal and installation
• Parking brake shoes - removal and installation
• Stop light switch - removal and installation
• Anti-lock braking system (ABS) - general information
• Anti-lock components - removal and installation
• Vacuum pump - removal and installation

• General Information
• Front hub assembly - removal and installation
• Front tail-vise of swivel pin - removal and installation
• Front pillar - removal, overhaul and installation
• Front levers / rack - removal, overhaul and installation
• Ball joint for front lever - replacement
• Front anti-roll bar - removal and installation
• Connecting rod of the stabilizer of cross-section stability - removal and installation
• Rear hub assembly - replacement
• Rear hub bearing replacement
• Rear shock absorber - removal, overhaul and installation
• Rear helical spring - removal and installation
• Shaft of rear swivel pin - removal, overhaul and installation
• Rear levers / racks - removal, overhaul and installation
• Rear anti-roll bar - removal and installation
• Steering wheel - removal and installation
• Steering column - removal, inspection and installation
• The mechanism for locking the steering column - general information
• Intermediate shaft of the steering column - removal and installation
• Rack-and-pinion steering gear assembly - removal, overhaul and installation
• Power steering pump - removal and installation
• Hydraulic power steering circuit - pumping
• Active Steering control unit - removal and installation
• Rubber anthers of the steering rack - replacement
• Tips of transverse steering rods / ball joints - removal and installation
• The cross-section steering draft - replacement
• Dynamic stability control (dsc) - general information and component replacement)
• Wheel alignment angles - general information

• General information
• Maintenance - body and frame
• Maintenance - upholstery and rugs
• Elimination of minor body damage - repairs
• Removing serious body damage - general information
• Front bumper - removal and installation
• Rear bumper - removal and installation
• Hood - removal, installation and adjustment
• Hood opening cable - removal and installation
• Hood lock - removal and installation
• Doors - removal, installation and adjustment
• Internal door trim panels - removal and installation
• Handle and door lock components - removal and installation
• Glass lifters and regulator - removal and installation
• Lid / tailgate and support pillars - Removing and installing
• Components of the lid / tailgate lock - removal and installation
• Components of the central lock - removal and installation
• Components of electric glass lifts - removal and installation
• Mirrors and related components - removal and installation
• Windshield and rear window - general information
• Hatch - general information, servo replacement and initialization
• Exterior elements of the body - removal and installation
• Seats - removal and installation
• System of pretensioners of seat belts - general information
• Safety belt components - removal and installation
• Internal cladding panels - removal and installation
• Central console - removal and installation
• Fixing panel assembly - removal and installation

• General Information
• Detection of malfunctions in the electrical system - general information
• Fuses and relays - general information
• Switches - removal and installation
• Lamps (external lighting) - replacement
• Lamps (interior lighting) - replacement
• External headlamps - removal and installation
• Adjusting the height of the headlights - general information
• Dashboard - removal and installation
• Components of the instrument panel - removal and installation
• Rain sensor - removal and installation
• Suspension height sensor - removing and installing
• Tire pressure monitoring system indicator - general information
• Acoustic signal - removal and installation
• Wiper arm - removal and installation
• Draft and wiper drive - removal and installation
• Components of the windshield washer system / headlights - removal and installation
• Audio system unit - removal and installation
• Speakers - removal and installation
• Radio antenna - general information
• Cruise control system - general information and component replacement
• Anti-theft system - general information
• Components of the heated front seats - removal and installation
• Airbag System - General Information and Precautions
• Components of the airbag system - removal and installation
• Parking assist system (PDC) - general information and component replacement
• Electrical diagrams - general information

• Dimensions and weight
• Vehicle identification numbers
• General repair procedures
• Lifting the car with a jack, the points of the pillars
• Tools and devices
• Checking the technical condition of the car
• Troubleshooting