Найти книгу: "International 7400 since 2006 Parts Catalog"

Content Parts catalog guide Line set ticket Engine line set ticket Engine performance / specifications I-530 engine Durability Maintenance Performance Specifications Standard equipment I-530 high torque engine Durability Maintenance Performance Specifications Standard equipment Frame Bolt-on frame extension Frame rail sidemember Bumper Radiator Crossmember Front recovery devices Front axle Axle, hub Housing Axle shaft Diff and gearing Differential Kit diff Tie rod,arms and knuckle Arm,strg tie rod, knuckle, tie Rod assy,tie Turn angle Upper STRG arm Chassis springs Bracket Spring,chassis front Brakes ABS speed sensor Air brk tubing Harness,nylon tube assy Valve Air compsr and governor Air compsr tubing Air dryer Cooler,air brake or dryer Air dryer tubing Hose, assembly components Air solenoid Air tank fittings Brake,primary air tank fittngs Air tank tubing Brake Tank,air quality connect assy Brake accessories module Kit, stop light switch Kit, ABS bracket Pedal,brake Valve Chamber Drain valve Electronic control unit Axle hosing Manifold Seal, seat belt Steering gear figure Power steering reservoir Brace Shaft,steering Gear,asm steering Link Elbow,flared tube Steering column Steering wheel Propeller shafts figure Input yoke Flange,trun Kit, U-JT strap and bolt Output yoke Prop shaft Exhaust figure Muffler Turbo pipe Electrical figure Air solenoid Bracket,solenoid Air solenoid valve Alternator Generator Back-up alarm wiring Batt box cover Batteries Battery box tray Bracket,left batt box support Bracket,right batt bos support Battery cable saddle and plug Battery equalizer module Battery wiring Center chassis harness Dash harness Harn,dlink,cab Electrical service Light,head Light,turn signal Fuse panel Radio antenna Valve, air solenoid Front sheet metal Fender extensions; front end Reinforcement Grille Hood Cable,hood safety Hood latch Hood support Mud guard Splash panel Miscellaneous Lug wrench and handle Clutch Clutch controls Clutch pedal Kit,clutch pedal Lever,bellcrank clutch Engines Rocker arm unit Manifold Cylinder head unit Arm,valve rocker Deartn/surge tank decal Engine compression brake effects Deartn hosing Sleeve Damper Crankcase Cover, coolant filter Cooling package Cooler, oil Sensor Harness Camshaft Pipe,air cold side Bracket, alternator leece-neville Arm, rocker Air restriction gauge Seal,cooling recirc Kit,recirc hardware Air recirculation seals Compressor Air compressor Air cleaner Accel pedal Shaft Side venting breather Valve cover Engine core Oil level gauge Engine core Fuel injector unit Hydraulic fuel system unit Idler gear unit Injector Kit,piston ring Oil cooler unit Oil filter Oil filter unit Package front oil seal Tappet unit Vibration damper unit Water pump Sub-sect, coolant conditioner unit Auto tensioner unit Fan drive hosing Flywheel Rear oil seals unit Fuel system, hydraulic Plug assy Front engine mounts unit Thermostat unit Pistons Power steering pump Radiator Starting motor Tappets, valve Tensioner Thermostat Transmission Clutch Housing Retainer Shift bar Transfer case Rear axle Differential Axle controls Breather cover Lift axle controls Axle plug chart Shock absorber Suspension beam Transverse torque rod Fuel tanks Fuel hosing Tube,fuel line Fuel tank module Cab A/C compsr Air horn Cab,regular complete Door Frame Panel Reinforcement Cab dash interior trim Bracket Crossmember Cab sealing Clearance Handle,window regulator Seat Floor mat Light Air conditioner, Interior trim Mirror Product graphic Rear window Scuff plate Switch Wheels Fluid Wheel end Hubs and drums Wheel hub Rear wheel Seal Spare wheel Valve,tubeless tire Tire valve and cap Appendix Abbreviations Part description index Part number index

Content

Introduction

Actions in emergency situations

• Engine overheating actions
• Starting the engine from the battery of another car
• Fuse replacement
• Wheel replacement
• Towing a car

Daily checks and troubleshooting Operation of the car in the winter

Trip to the RST

Operation and maintenance manual

• General information
• Vehicle operation
• Car service
• Technical specifications

Precautions and safety rules when working on a car Basic tools, measuring instruments and methods of working with them

• Basic set of necessary tools
• Methods of working with measuring devices

Engine

• Technical data
• Diagnosis and maintenance
• Cylinder head and timing drive
• Cylinder block
• Annex to chapter

Power and engine management system

• Technical data
• Power system
• Fuel supply system
• Annex to chapter

Lubrication system

• Technical data
• Oil pan
• Oil pump
• Oil filter

Cooling system

• Technical data
• System maintenance
• Elements of the cooling system

The intake and exhaust system

• Intake manifold
• Release system

Transmission

• Technical data
• 5-speed complete transmission with final drive
• Differential
• Clutch
• Appendix to chapter

Power shafts

• Drive shafts
• Appendix to chapter

Chassis

• Technical data
• Front wheel hub and wheel hub
• Rear wheel hub and wheel hub
• Wheels and tires
• Appendix to chapter

Brake system

• Technical data
• Brake service
• Elements of a hydrodrive of brakes
• Front brakes
• Rear brakes
• Parking brake
• Anti-lock braking system (ABS)
• Appendix to chapter

Steering

• Technical data
• Power steering
• Electric power steering
• Appendix to chapter

Body

• Interior
• Exterior
• Doors
• Seats
• Body dimensions

Heating, ventilation and air conditioning system

• Technical data
• Air conditioning and ventilation
• Heating system
• Appendix to chapter

Passive safety system

• Airbags
• Seat belts
• Appendix to chapter

Electrical equipment and electrical systems

• Rechargeable battery and charging system
• Starting system
• Control units
• Immobilizer
• Lighting system
• Beep
• Wire harnesses

Electroschemes

• Fuel system
• Cooling system
• Fuel system
• Heating and air conditioning system
• Pillows and safety belts
• Heating and air conditioning system
• Audio system
• Light sources in the salon
• Beep
• Dashboard
• Front body control unit
• Coal adsorber consumption valve
• Ignition system
• Electromechanical lock system
• Electromechanical window drive system
• Parking lights, rear lights and registration number lights
• Power and mass chains
• Electronic control of engine systems

Parts catalog Explanatory dictionary

Content

Actions in emergency situations

• Emergency start
• Start from an external source
• Forced start of the engine
• If the tire is punctured
• If the fuse is blown
• If the battery is low
• Lifting the car
• Towing the car
• In case of a traffic accident

Daily checks and troubleshooting Instruction manual

• Basic information
• Keys, locks and security system
• Seats, belts and airbags
• Instrumentation and controls
• Heating and cooling control
• Systems and equipment
• Car maintenance
• Technical specifications

Precautions and safety rules when working on a car Basic tools, measuring instruments and methods of working with them

• Basic set of necessary tools
• Methods of working with measuring devices

Mechanical part of the engine (diesel engines)

• General information
• Removing and installing engine (together with gearbox)
• The head of the block of cylinders, valves, a belt of a drive газораспределительного the mechanism
• Cylinder block
• Crankshaft Oil Seals
• V-Ribbed belt of accessories drive
• Service data and specification

Mechanical part of the engine (petrol engines)

• General information
• Removing and installing engine (together with gearbox)
• Cylinder Head, Valves
• Cylinder block
• Crankshaft oil seals
• V-ribbed belt for additional equipment
• Timing belt
• Service data and specification

Cooling system

• Coolant expansion tank
• Radiator
• The pump of a cooling liquid
• Thermostat
• Cooling Fan
• Service data and specification

Lubrication system

• Car service
• Oil dipstick tube
• Oil pump
• Oil collector
• The oil filter
• Sensors
• Engine oil cooling system (diesel engines)
• Service data and specification

Power system

• Precautions for repair
• Power system for diesel engines
• Power system for gasoline engines
• Fuel tank and components (for all types of engines)
• Service data and specification

Engine management system

• Petrol engine control system
• Diesel engine management system

The intake and exhaust system

• Intake manifold
• An exhaust manifold
• Exhaust pipe and silencers
• Turbocharging
• Exhaust Gas Recirculation (EGR)
• Service data and specification

Engine electrical equipment

• Charging system
• Starting system
• Ignition system (for petrol engines)
• Pre-post-post heating system (for diesel engines)
• Service data and specification

Clutch

• General information
• Precautions for repair
• Car service
• Clutch
• Clutch drive
• Service data and specification

Transmission

• General information (manual transmission)
• Manual transmission
• Automatic transmission
• Transfer case (cars with all-wheel drive)
• Service data and specification

Drive shafts and final drives

• Power shafts
• Cardan shaft (cars with four-wheel drive)
• Differential
• Rear axle (all-wheel drive vehicles)
• Service data and specification

Suspension

• Front suspension
• Rear suspension
• Wheels and tires
• Service data and specification

Brake system

• Car service
• Components of brake system
• Front brakes
• Rear disc brakes
• Rear drum brakes
• Parking brake system
• Antiblocking system of brakes (ABS)
• Service data and specification

Steering

• Car service
• Steering wheel, steering shaft, contact disk
• Steering gear
• Tips of steering drafts
• Power Steering
• Service data and specification

Body

• General information
• Interior
• Exterior
• Body dimensions
• Service data and specification

Passive security

• General information
• Electronic control unit
• Airbag modules
• Sensors and switch of airbags
• Seat belts
• Disposal of airbag modules
• Service data and specification

Air conditioning and heating system

• General information
• Heating system
• Air conditioning system
• Service data and specification

Electroschemes and connectors

• Description of the electric circuit
• Electroschemes

Explanatory dictionary

• Abbreviations

Content

Introduction

Car operation, maintenance, and repair guide

Technical data, characteristics of units and equipment

• Marking cars
• Technical specifications
• Adjustment data
• Refueling volumes
• Basic dimensions of a car
• Engine
• Transmission
• Chassis
• Brakes
• Cabin
• Cabin equipment
• Steering
• Electrical equipment
• Air conditioning

Safety requirements when operating a car

• The correct fit of the driver
• Starting the engine
• Starting the engine at low temperatures
• Stopping the engine
• Start of movement and speed change
• Motion control

Maintenance

• Scope of work by type of maintenance
• Daily maintenance
• Seasonal service
• List of works by type of maintenance
• Lubrication of the car

Preparing the car for work after getting it from the factory

• Checking a new car

Run-in of a new car

• Run-in of a new car

Maintenance of serviceable condition and maintenance of vehicle systems and units

• The engine and its systems
• Engine suspension
• Cylinder head
• Gas distribution mechanism
• Lubrication system
• Cooling system
• Fuel system
• Transmission
• Chassis
• Steering
• Brakes
• Electrical equipment
• Tools and accessories

Conservation and re-opening

• Conservation
• Rescreening

Applications

• Tightening torques for critical threaded connections
• Lamps used on cars
• Reinforced cuffs

Engine

• Features of engine maintenance and repair
• Engine CA4DC2 - 10E3 (12E3) of vehicles BJ1044, 1065 (removal and installation, disassembly and assembly)
• Motors 4100QBZ-2, 4100QBZL, 4100QBZL-2, 4102QBZL (removal and installation, disassembly and assembly)
• Features of maintenance of engine management systems for BAW (EURO-3) vehicles
• Application of "NF-3105-M" oil filter on FAW vehicles "BAW"
• Basic methods of engine control with the help of external diagnostic tools

Cooling system

• System description
• Main cooling system malfunctions and methods of their elimination
• Operation of the cooling system
• Elimination of damage to the heater hose (owner's advice)

Transmission

• Differences between BAW vehicles in EURO 2 and EURO 3
• Transmission of vehicles BJ1044, 1065 (removal and installation, disassembly and assembly)
• Transmission LC5T35 (C2Q01) (BP10651710201)

Suspension and suspension

• Bridge front
• Rear axle of BAW vehicles BJ1044,1065 (removal, installation and repair of the reducer)
• Cardan transmission of vehicles BJ1044, 1065 (removal, installation and repair)
• Adjusting the bearings of the hubs
• Lubrication of the spring axis
• Node node
• Recommendations for the application of tires of various manufacturers on vehicles BAW BJ1044 and BAW BJ1065

Steering

• System maintenance
• Power steering
• Possible steering malfunctions and solutions
• The procedure for changing the oil of GUR on BAW vehicles

Brake system

• BAW pneumatic brake system
• Automatic brake force regulator BJ1044
• Antilock braking system BJ1065
• Compressor
• Air dehumidifier
• Four-circuit safety valve
• Brake valve
• Automatic rear brake lever
• Quick release valve
• Brake chambers
• Malfunctions of brake system
• Parking brake system disassembly and assembly
• The mechanism of automatic adjustment of a backlash of brake колодок the back bridge
• Replacing the oil separator (dehydrator)
• Disassembly and assembly of the main elements of the brake system
• Parking brake system, disassembly and assembly
• Disassembling a car compressor
• Assessment of technical condition and repair of the braking system
• Maintenance

Body and salon

• Torsion bar adjustment
• Windshield wiper ZD 1331 (1333) of vehicles BJ1044, 1065 (removal, installation and repair)

Air conditioning and ventilation system

• Air Conditioning
• The device and operating principle of the air-conditioning system of the BAW car cabin

Electrical equipment

• Rechargeable battery (battery)
• Generator
• Starter
• Mounting blocks (relays and fuses)
• Lighting system and light signaling
• Removing and repairing the generator
• Removal and repair of a starter of cars BJ1044,1065 (EURO-3)
• Changing the switching circuit of the headlamp relay coil (high beam) on vehicles BAW 1044
• Connecting the security alarm on vehicles BAW 1044, 1065
• Electrofanning device of car BJ 1065 (EURO-2)
• Electroschemes

Content

Introduction

Instruction manual

• Controls
• Required information
• Start and control
• Solution in case of emergency

Maintenance

• Corrosion prevention and periodic maintenance
• Technical operations on a car
• Technical parameters of the car

Mechanical part of the engine

• General information
• Engine repair
• Cylinder head
• Cylinder assembly

Lubrication system

• Technical operations on a car
• Oil filter
• Oil pump

Cooling system

• General information
• Cooling fluids
• Water pump

Engine electrical equipment

• Ignition system
• Starting and charging system

Clutch

• General information
• Clutch pedal
• Master cylinder
• Clutch release cylinder
• Clutch module

Transmission

• General information
• Manual transmission
• Differential

Suspension and drive shafts

• General information
• Technical operations on a car
• Front suspension
• Rear suspension

Brake system

• General information
• Brake pedal
• Parking brake
• Master cylinder
• Vacuum amplifier
• Front brake shoe
• Front brake caliper
• Rear brake drum
• Anti-lock braking system

Steering

• General information
• Drive belt
• Steering column
• Power steering pump
• Direct-acting steering gear
• Power steering

Body

• General information
• Bumpers
• Headlamps
• Rear combination lamp
• The hood
• Front door
• Back door
• Trunk door
• Front windscreen wipers and washer
• Rear window wiper and washer
• Windscreen

Air conditioning system

• General information
• Diagnosis of A / C system failures
• Compressor drive belt
• Arrangement of the air conditioning ducts

Electrical equipment of a car

• General information
• Combined instrument cluster
• Glass lifts
• Lighting system
• Combined switches
• The device of the central blocking of door locks
• Relay and fuse block
• Electroschemes

Parts catalog Abbreviation index

Content

Actions in emergency situations

• Problems when starting the engine
• Starting the engine from an external source
• If the engine stalled while driving
• Engine overheating
• In the case of a wheel puncture
• Towing a car

Daily checks and troubleshooting Operation and maintenance

• General information
• Instrument panel and controls
• Instrument cluster
• Keys
• Subsea switches
• Driving
• Car maintenance

Precautions and safety rules when working on a car Basic tools, measuring instruments and methods of working with them

• Basic set of necessary tools
• Methods of working with measuring devices

Mechanical part of the engine

• General information
• Technical condition check
• Replacing drive belts
• Adjusting the valve clearance
• Engine components
• Changing the timing belt
• Replacing the camshaft
• Replacing cylinder head gasket
• Cylinder assembly
• Oil pump oil seal replacement
• Replacement of the crankshaft rear oil seal
• General engine malfunctions and their elimination
• Service data and specification
• Spare parts catalog

Cooling system

• General information
• Checking the cooling system
• Replacing the water pump, thermostat and radiator
• Spare parts catalog

Lubrication system

• Technical operations on a car
• Replacing the oil pressure sensor
• Replacing the oil pan
• Replacing the oil filter
• Spare parts catalog

Power system

• Checking the pressure in the fuel system
• Checking the fuel pump
• Replacing fuel injectors
• Replacing the fuel pump
• Replacement of the adsorber
• Spare parts catalog

Engine management system

• General information
• System structure and operating principle
• Spare parts catalog

The intake and exhaust system

• Throttle Body
• Exhaust system
• Spare parts catalog

Engine electrical equipment

• Ignition system
• Engine start system
• Charge system
• Spare parts catalog

Clutch

• Replacement of clutch
• Clutch drive
• Hydraulic clutch control
• Spare parts catalog

Transmission

• General information
• Replacing the gearbox
• Replacing the speedometer drive
• Replacing transmission gland
• Replacing the radial shaft seal
• Gearbox control
• Traction gear drive
• Cable shift gear
• Spare parts catalog

Power shafts

• Drive shaft
• Spare parts catalog

Chassis

• General information
• Front suspension
• Rear suspension
• Wheels
• Spare parts catalog

Brake system

• General information
• Brake pedal
• Vacuum amplifier and brake master cylinder
• Front brake
• Rear brake
• Pipelines of brake system
• Parking brake
• Anti-lock braking system
• Spare parts catalog

Steering

• Steering gear with hydraulic booster
• Steering
• Power steering pipelines
• Steering rack with hydraulic booster
• Spare parts catalog

Body

• Description of car body parts
• Removing and installing exterior, interior panels and accessories
• Body structure
• Types of body damage and repair requirements
• Standard body repair technology
• Damage repair
• Specifications and structure of the body of a car
• Vibration reduction and soundproofing
• Body parameters
• Spare parts catalog

Passive safety system

• General information
• Troubleshooting
• Replacement
• Spare parts catalog

Air conditioning system

• General information
• Heating system
• Air conditioning control system
• Service instructions
• Maintenance of air conditioning
• Basic elements
• Checking and troubleshooting of air conditioning
• Spare parts catalog

Electroschemes and connectors

• Overview
• Instrument panel
• Windscreen wiper and washer
• Lighting system
• Audio system
• Synchronization of the high-frequency remote control of the central lock
• Using the K61 diagnostic tool
• Electroschemes
• Spare parts catalog

Trouble codes Explanatory dictionary

• Abbreviations